Active Height Control Suspension Data List / Active Test

Suspension. Land Cruiser. Urj200, 202 Grj200 Vdj200
Suspension Control. Land Cruiser. Urj200, 202 Grj200 Vdj200

  1. READ DATA LIST

  1. PERFORM ACTIVE TEST

Active Height Control Suspension -- Data List / Active Test



READ DATA LIST
HINT:
Using the GTS to read the Data List allows the values or states of switches, sensors, actuators and other items to be read without removing any parts. This non-intrusive inspection can be very useful because intermittent conditions or signals may be discovered before parts or wiring is disturbed. Reading the Data List information early in troubleshooting is one way to save diagnostic time.
NOTICE:
In the table below, the values listed under "Normal Condition" are reference values. Do not depend solely on these reference values when deciding whether a part is faulty or not.

  1. Turn the engine switch off.

  2. Connect the GTS to the DLC3.

  3. Turn the engine switch on (IG) and the GTS on.

  4. Enter the following menus: Chassis / AHC / Data List.

  5. According to the display on the GTS, read the Data List.

    AHC
    Tester Display
    		Measurement Item/Range
    		Normal Condition
    		Diagnostic Note
    (Up&Down)G Sensor FR
    		G (up and down) front acceleration sensor RH reading /
    min.: -1045.29 m/s2
    max.: 1045.26 m/s2
    		0 +/-0.98 m/s2 at still condition.
    		Reading changes when vehicle (Front RH) is bounced.
    (Up&Down)G Sensor FL
    		G (up and down) front acceleration sensor LH reading /
    min.: -1045.29 m/s2
    max.: 1045.26 m/s2
    		0 +/-0.98 m/s2 at still condition.
    		Reading changes when vehicle (Front LH) is bounced.
    (Up&Down)G Sensor Rear
    		G (up and down) rear acceleration sensor reading /
    min.: -1045.29 m/s2
    max.: 1045.26 m/s2
    		0 +/-0.98 m/s2 at still condition.
    		Reading changes when vehicle (Rear) is bounced.
    (Back&Forth)G Sensor
    		G sensor reading /
    min.: -4.5952 m/s2
    max.: 4.5953 m/s2
    		0 +/-0.98 m/s2 at still condition.
    		Reading changes when vehicle is bounced.
    Oil Pressure Sensor
    		Fluid pressure sensor reading /
    min.: -784.79 MPa (-8002.540 kgf/cm2, -113824.688 psi)
    max.: 784.76 MPa (8002.296 kgf/cm2, 113821.215 psi)
    		-
    		-
    Oil Temperature Sensor
    		Fluid temperature sensor reading /
    min.: -3276.8°C (-5866.24°F)
    max.: 3276.7°C (5930.06°F)
    		-
    		-
    Gravity Sensor(Side to Side)
    		Yaw rate sensor information /
    min.: -1176.37 m/s2
    max.: 1176.33 m/s2
    		-
    		-
    FR Height Control Sensor
    		Front height control sensor RH reading /
    min.: -3276.8 mm (-129 in.)
    max.: 3276.7 mm (129 in.)
    		-
    		-
    FL Height Control Sensor
    		Front height control sensor LH reading /
    min.: -3276.8 mm (-129 in.)
    max.: 3276.7 mm (129 in.)
    		-
    		-
    RR Height Control Sensor
    		Rear height control sensor RH reading /
    min.: -3276.8 mm (-129 in.)
    max.: 3276.7 mm (129 in.)
    		-
    		-
    RL Height Control Sensor
    		Rear height control sensor LH reading /
    min.: -3276.8 mm (-129 in.)
    max.: 3276.7 mm (129 in.)
    		-
    		-
    Height Offset Max
    		Display of amount of vehicle height calibration that is possible /
    min.: 0 mm (0 in.)
    max.: 655.35 mm (25.801 in.)
    		min.: 0 mm (0 in.)
    max.: 20 mm (0.787 in.)
    		-
    FR Height Adjust
    		Display of vehicle height offset recorded value of front right wheel /
    min.: -3276.8 mm (-129 in.)
    max.: 3276.7 mm (129 in.)
    		-
    		-
    FL Height Adjust
    		Display of vehicle height offset recorded value of front left wheel /
    min.: -3276.8 mm (-129 in.)
    max.: 3276.7 mm (129 in.)
    		-
    		-
    RR Height Adjust
    		Display of vehicle height offset recorded value of rear right wheel /
    min.: -3276.8 mm (-129 in.)
    max.: 3276.7 mm (129 in.)
    		-
    		-
    RL Height Adjust
    		Display of vehicle height offset recorded value of rear left wheel /
    min.: -3276.8 mm (-129 in.)
    max.: 3276.7 mm (129 in.)
    		-
    		-
    FR After Height Adjust
    		Display of after-calibration vehicle height value of front right wheel /
    min.: -3276.8 mm (-129 in.)
    max.: 3276.7 mm (129 in.)
    		-
    		-
    FL After Height Adjust
    		Display of after-calibration vehicle height value of front left wheel /
    min.: -3276.8 mm (-129 in.)
    max.: 3276.7 mm (129 in.)
    		-
    		-
    RR After Height Adjust
    		Display of after-calibration vehicle height value of rear right wheel /
    min.: -3276.8 mm (-129 in.)
    max.: 3276.7 mm (129 in.)
    		-
    		-
    RL After Height Adjust
    		Display of after-calibration vehicle height value of rear left wheel /
    min.: -3276.8 mm (-129 in.)
    max.: 3276.7 mm (129 in.)
    		-
    		-
    Stop Light Switch
    		Stop light switch /
    ON or OFF
    		ON: Brake pedal depressed.
    OFF: Brake pedal released.
    		-
    COMFORT Switch
    		-
    		-
    		This item is not used
    SPORT Switch
    		-
    		-
    		This item is not used
    Door Switch
    		Door switch /
    ON or OFF
    		ON: Door open.
    OFF: All doors closed.
    		-
    Access Mode Switch
    		-
    		-
    		This item is not used
    Height Control Switch(Up)
    		Height control switch (Up) /
    ON or OFF
    		ON: Up button of the height control switch pushed.
    OFF: Height control switch not pushed.
    		-
    Height Control Switch(Down)
    		Height control switch (Down) /
    ON or OFF
    		ON: Down button of the height control switch pushed.
    OFF: Height control switch not pushed.
    		-
    Height Offset
    		Vehicle height offset calibration condition reading /
    ON or OFF
    		ON: Vehicle height offset calibration complete.
    OFF: Before vehicle height offset calibration.
    		-
    TD Terminal
    		TD terminal /
    ON or OFF
    		ON: Height control OFF switch pushed.
    OFF: Height control OFF switch not pushed.
    		-
    TC Terminal
    		TC terminal /
    ON or OFF
    		ON: DTC output.
    OFF: DTC not output.
    		-
    TS Terminal
    		TS terminal /
    ON or OFF
    		ON: During test mode.
    OFF: Normal mode.
    		-
    Differential Lock Switch
    		Center differential lock switch /
    ON or OFF
    		ON: Center differential locked.
    OFF: Center differential free.
    		-
    L4 Switch
    		Transfer position switch /
    ON or OFF
    		ON: Transfer position switch set to L4.
    OFF: Transfer position switch set to H4.
    		-
    IG Power Source Voltage
    		ECU power supply voltage /
    min.: 0 V
    max.: 25.5 V
    		Engine switch on (IG): 11 to 14 V
    		-
    +B Power Source Voltage
    		Power supply for damping force control actuator /
    min.: 0 V
    max.: 25.5 V
    		Engine switch on (IG): 11 to 14 V
    		-
    +B2 Power Source Voltage
    		Power supply for No. 1 height control valve and front suspension control valve /
    min.: 0 V
    max.: 25.5 V
    		Engine switch on (IG): 11 to 14 V
    		-
    Steering Angle
    		Steering angle sensor reading /
    min.: -49152°
    max. 49150.5°
    		Actual steering angle.
    Left turn: reading increases.
    Right turn: reading decreases.
    		-
    Engine Speed
    		Engine speed /
    min.: 0 rpm
    max.: 25500 rpm
    		Actual engine speed.
    		Speed indicated on the combination meter.
    FR Wheel Speed
    		Front right wheel speed reading /
    min.: 0 km/h (0 mph)
    max.: 255 km/h (159 mph)
    		-
    		-
    FL Wheel Speed
    		Front left wheel speed reading /
    min.: 0 km/h (0 mph)
    max.: 255 km/h (159 mph)
    		-
    		-
    RR Wheel Speed
    		Rear right wheel speed reading /
    min.: 0 km/h (0 mph)
    max.: 255 km/h (159 mph)
    		-
    		-
    RL Wheel Speed
    		Rear left wheel speed reading /
    min.: 0 km/h (0 mph)
    max.: 255 km/h (159 mph)
    		-
    		-
    Driving Torque
    		Actual driving torque /
    min.: -1024 Nm
    max.: 1023 Nm
    		-
    		-
    Damper Step FR
    		Damper step (Front RH) /
    min.: 1 step
    max.: 255 step
    		min.: 1 step
    max.: 16 step
    		-
    Damper Step FL
    		Damper step (Front LH) /
    min.: 1 step
    max.: 255 step
    		min.: 1 step
    max.: 16 step
    		-
    Damper Step RR
    		Damper step (Rear RH) /
    min.: 1 step
    max.: 255 step
    		min.: 1 step
    max.: 16 step
    		-
    Damper Step RL
    		Damper step (Rear LH) /
    min.: 1 step
    max.: 255 step
    		min.: 1 step
    max.: 16 step
    		-
    Max Damper Step FR
    		Damper step (Front RH) /
    min.: 0 step
    max.: 255 step
    		16 step
    		-
    Max Damper Step FL
    		Damper step (Front LH) /
    min.: 0 step
    max.: 255 step
    		16 step
    		-
    Max Damper Step RR
    		Damper step (Rear RH) /
    min.: 0 step
    max.: 255 step
    		16 step
    		-
    Max Damper Step RL
    		Damper step (Rear LH) /
    min.: 0 step
    max.: 255 step
    		16 step
    		-
    Adaptive Variable Suspension(AVS) Mode
    		Adaptive variable suspension mode /
    NORMAL / COMFORT / SEMI CO / SEMI SP / SPORTS
    		Actual conditions displayed.
    		-
    Height Mode
    		Height mode /
    NORMAL / ACCE LO / LO / STAN LO / FAST LO / L4 HI / HI / EX HI / LUGG LO
    		Actual conditions displayed.
    		-
    Access Mode
    		-
    		-
    		This item is not used
    Height Control Prohibition
    		Vehicle height control prohibition information /
    Permiss or Prohibi
    		Actual conditions displayed.
    		-
    Front Right Height Solenoid
    		Front height solenoid RH /
    ON or OFF
    		-
    		-
    Front Left Height Solenoid
    		Front height solenoid LH /
    ON or OFF
    		-
    		-
    Rear Right Height Solenoid
    		Rear height solenoid RH /
    ON or OFF
    		-
    		-
    Rear Left Height Solenoid
    		Rear height solenoid LH /
    ON or OFF
    		-
    		-
    Front Gate Valve
    		Front gate valve /
    ON or OFF
    		-
    		-
    Rear Gate Valve
    		Rear gate valve /
    ON or OFF
    		-
    		-
    Accumulator Valve
    		Accumulator valve /
    ON or OFF
    		-
    		-
    FR Gas spring Switch Valve
    		Front gas spring switch valve RH /
    ON or OFF
    		-
    		-
    FL Gas spring Switch Valve
    		Front gas spring switch valve LH /
    ON or OFF
    		-
    		-
    Pump Motor Relay
    		Pump motor relay /
    ON or OFF
    		-
    		-
    Main Relay for Valve
    		Main relay for valve /
    ON or OFF
    		-
    		-
    Main Relay for Actuator
    		Main relay for actuator /
    ON or OFF
    		-
    		-
    Number of Trouble Codes
    		Number of DTCs recorded /
    min.: 0
    max.: 255
    		-
    		-


PERFORM ACTIVE TEST
HINT:
Using the GTS to perform Active Tests allows relays, VSVs, actuators and other items to be operated without removing any parts. This non-intrusive functional inspection can be very useful because intermittent operation may be discovered before parts or wiring is disturbed. Performing Active Tests early in troubleshooting is one way to save diagnostic time. Data List information can be displayed while performing Active Tests.

  1. Turn the engine switch off.

  2. Connect the GTS to the DLC3.

  3. Start the engine.

  4. Turn the GTS on.

  5. Enter the following menus: Chassis / AHC / Active Test.

  6. According to the display on the GTS, perform the Active Test.

    AHC
    Tester Display
    		Test Part
    		Control Range
    		Diagnostic Note
    Damper Step FR
    		Changes front damper RH step
    		min.: 1 step
    max.: 16 step
    		The Damper Step item of the Data List changes to the step selected in the Active Test.
    Damper Step FL
    		Changes front damper LH step
    		min.: 1 step
    max.: 16 step
    		The Damper Step item of the Data List changes to the step selected in the Active Test.
    Damper Step RR
    		Changes rear damper RH step
    		min.: 1 step
    max.: 16 step
    		The Damper Step item of the Data List changes to the step selected in the Active Test.
    Damper Step RL
    		Changes rear damper LH step
    		min.: 1 step
    max.: 16 step
    		The Damper Step item of the Data List changes to the step selected in the Active Test.
    Front Right Height Solenoid
    		Front height control solenoid valve RH
    		ON or OFF
    		Operation of solenoid can be heard.
    Front Left Height Solenoid
    		Front height control solenoid valve LH
    		ON or OFF
    		Operation of solenoid can be heard.
    Rear Right Height Solenoid
    		Rear height control solenoid valve RH
    		ON or OFF
    		Operation of solenoid can be heard.
    Rear Left Height Solenoid
    		Rear height control solenoid valve LH
    		ON or OFF
    		Operation of solenoid can be heard.
    Front Gate Valve
    		Front gate valve
    		ON or OFF
    		When the Front Gate Valve item of the Active Test is operated, the Front Gate Valve item of the Data List changes to ON/OFF.
    Rear Gate Valve
    		Rear gate valve
    		ON or OFF
    		When the Rear Gate Valve item of the Active Test is operated, the Rear Gate Valve item of the Data List changes to ON/OFF.
    Accumulator Valve
    		Accumulator valve
    		ON or OFF
    		Operation of solenoid can be heard.
    FR Gas Spring Switch Valve
    		Front gas spring switch valve RH
    		ON or OFF
    		When the FR Gas Spring Switch Valve item of the Active Test is operated, the FR Gas Spring Switch Valve item of the Data List changes to ON/OFF.
    FL Gas Spring Switch Valve
    		Front gas spring switch valve LH
    		ON or OFF
    		When the FL Gas Spring Switch Valve item of the Active Test is operated, the FL Gas Spring Switch Valve item of the Data List changes to ON/OFF.
    Front Right Wheel Up/Down
    		Right front vehicle height
    		UP, DOWN or OFF
    		-
    Front Left Wheel Up/Down
    		Left front vehicle height
    		UP, DOWN or OFF
    		-
    Rear Right Wheel Up/Down
    		Right rear vehicle height
    		UP, DOWN or OFF
    		-
    Rear Left Wheel Up/Down
    		Left rear vehicle height
    		UP, DOWN or OFF
    		-
    Front Wheel Up/Down
    		Front vehicle height
    		UP, DOWN or OFF
    		-
    Rear Wheel Up/Down
    		Rear vehicle height
    		UP, DOWN or OFF
    		-
    Front Wheel Up by Accumulator
    		Raising of front vehicle height
    		UP or OFF
    		-
    Rear Wheel Up by Accumulator
    		Raising of rear vehicle height.
    		UP or OFF
    		-