Meter / Gauge System Data List / Active Test

  1. DATA LIST

  1. ACTIVE TEST

Meter / Gauge System -- Data List / Active Test



DATA LIST
Using the GTS to read the Data List allows the values or states of switches, sensors, actuators and other items to be read without removing any parts. This non-intrusive inspection can be very useful because intermittent conditions or signals may be discovered before parts or wiring is disturbed. Reading the Data List information early in troubleshooting is one way to save diagnostic time.
NOTICE:
In the table below, the values listed under "Normal Condition" are reference values. Do not depend solely on these reference values when deciding whether a part is faulty or not.

  1. Turn the ignition switch to off.

  2. Connect the GTS to the DLC3.

  3. Turn the ignition switch to ON.

  4. Turn the GTS on.

  5. Enter the following menus:

    1. for Combination Meter: Body Electrical / Combination Meter / Data List.

    2. for ABS/VSC/TRC: Chassis / ABS/VSC/TRC / Data List.

    3. for Engine and ECT: Powertrain / Engine and ECT / Data List.

    4. for D-SEAT SW: Body Electrical / D-SEAT SW / Data List.

  6. Check the values by referring to the table below.

    1. Combination Meter

      Combination Meter
      Tester Display
      		Measurement Item/Range
      		Normal Condition
      		Diagnostic Note
      ODO/TRIP Change SW
      		ODO/TRIP switch/OFF or ON
      		OFF: ODO/TRIP switch released
      		-
      ON: ODO/TRIP switch pushed
      		-
      Tail Cancel SW*1
      		Tail cancel switch/OFF or ON
      		OFF: Tail cancel switch off
      		-
      ON: Tail cancel switch on
      P-Seatbelt Buckle SW
      		Front passenger side seat belt buckle switch/OFF or ON
      		OFF: Front passenger side seat belt unfastened
      		Perform the inspection while sitting in the front passenger side seat.
      ON: Front passenger side seat belt fastened
      Reverse Range Switch (6MT)*2
      		Shift position R signal/OFF or ON
      		OFF: Shift position except R
      		-
      ON: Shift position R
      Washer Switch*3
      		Level warning switch assembly/OFF or ON
      		OFF: Washer fluid level not low
      		-
      ON: Washer fluid level low
      Oil Level SW*4, *5
      		Engine oil level sensor/OFF or ON
      		OFF: Engine oil level low
      		-
      ON: Engine oil level except above
      Water Level SW*6
      		Level warning switch/OFF or ON
      		OFF: Water level switch off
      		-
      ON: Water level switch on
      Oil Pressure Switch
      		Oil pressure switch/OFF or ON
      		OFF: Engine oil pressure low
      		-
      ON: Engine oil pressure except above
      +B Voltage Value
      		Battery voltage/Min.: 0 V, Max.: 25.5 V
      		11 to 14 V
      		-
      Vehicle Speed Meter
      		Vehicle speed/Min.: 0 km/h (0 mph), Max.: 255 km/h (158 mph)
      		Almost same as actual vehicle speed
      		-
      Engine Rpm
      		Engine speed/Min.: 0 rpm, Max.: 12750 rpm
      		Actual engine speed
      		-
      Coolant Temperature
      		Engine coolant temperature/Min.: 0°C (0°F), Max.: 127.5°C (261.5°F)
      		75 to 100°C (167 to 212°F): After warming up the engine
      		-
      Fuel Input
      		Fuel input signal/Min.: 0, Max. 127.5
      		Current fuel level displayed
      		Unit: Liter
      Sub Fuel Input*7
      		Fuel input signal/Min.: 0, Max. 127.5
      		Current fuel level displayed
      		Unit: Liter
      TPMS Operation State*9
      		Tire pressure connection condition/ON, OFF or Unknown
      		Displays the tire pressure connection condition
      		-
      Integrated value for Timing belt*8
      		T-belt indicator integrated value/Min.: 0 km, Max.: 6553500km
      		0 to 6553500 km
      		-
      Ambient Temperature
      		Outside temperature/Min.: -40°C (-40°F), Max.: 87.5°C (189.5°F)
      		Almost the same as actual outside temperature
      		-
      Rheostat value
      		Light control rheostat switch input/Min.: 0, Max.: 100
      		Light control rheostat switch is fully turned right (0) → fully turned left (100)
      		Unit: %
      Units By Region*10
      		Unit of display setting/Km/l JP, Km/l, Mi/g US or Mi/g UK
      		Customized value displayed
      		-
      Language*10
      		Eng US / Eng UK / French / German / Spanish / Italian / Japanese / CHN Sim / CHN Trd / Russian
      		Customized value displayed
      		-
      Driver Side Seatbelt Warning Buzzer
      		Driver seat belt warning buzzer/OFF or ON
      		Customized value displayed
      		-
      P-Seatbelt Warning Buzzer
      		Front passenger seat belt warning buzzer/OFF or ON
      		Customized value displayed
      		-
      ECO Drive Indicator Zone*11
      		Condition of the eco drive indicator zone/OFF or ON
      		Customized value displayed
      		-
      TPMS System
      		Existence of function/With or Without
      		With: w/ Tire pressure warning system
      Without: w/o Tire pressure warning system
      		-
      Number of Trouble Code
      		The number of the DTC which is currently output/0 to 255
      		0
      		-

      1. *1: w/ TAIL Cancel Switch
      2. *2: for Manual Transmission (RA61F)
      3. *3: w/ Washer Fluid Level Warning System
      4. *4: for 1KD-FTV
      5. *5: for 1GR-FE, Europe
      6. *6: for Diesel Engine
      7. *7: for Double Tank Type
      8. *8: for 1KD-FTV, 5L-E
      9. *9: w/ Tire Pressure Warning System
      10. *10: for Analog Meter, Segment Display Type
      11. *11: for Automatic Transmission

    2. ABS/VSC/TRC

      ABS/VSC/TRC
      Tester Display
      		Measurement Item/Range
      		Normal Condition
      		Diagnostic Note
      FR Wheel Speed
      		Vehicle speed/Min.: 0 km/h (0 mph), Max.: 326 km/h (202 mph)
      		Almost same as actual vehicle speed
      		-
      FL Wheel Speed
      		Vehicle speed/Min.: 0 km/h (0 mph), Max.: 326 km/h (202 mph)
      		Almost same as actual vehicle speed
      		-
      RR Wheel Speed
      		Vehicle speed/Min.: 0 km/h (0 mph), Max.: 326 km/h (202 mph)
      		Almost same as actual vehicle speed
      		-
      RL Wheel Speed
      		Vehicle speed/Min.: 0 km/h (0 mph), Max.: 326 km/h (202 mph)
      		Almost same as actual vehicle speed
      		-
      Vehicle Speed
      		Vehicle speed/Min.: 0 km/h (0 mph), Max.: 326 km/h (202 mph)
      		Almost same as actual vehicle speed
      		-

    3. Engine and ECT

      Engine and ECT
      Tester Display
      		Measurement Item/Range
      		Normal Condition
      		Diagnostic Note
      Engine Speed
      		Vehicle speed/Min.: 0 rpm, Max.: 16383.75 rpm
      		Actual engine speed
      		-
      Coolant Temp
      		Engine coolant temperature/Min.: -40°C (-40°F), Max: 215°C (419°F)
      		75 to 100°C (167 to 212°F): After warming up the engine
      		-

    4. D-SEAT SW (w/ Multi-function Switch)

      D-SEAT SW
      Tester Display
      		Measurement Item/Range
      		Normal Condition
      		Diagnostic Note
      Steering Wheel Menu Switch
      		MENU switch/OFF or ON
      		OFF: MENU switch off
      		-
      ON: MENU switch on
      		-
      Steering Wheel Enter Switch
      		ENTER switch/OFF or ON
      		OFF: ENTER switch off
      		-
      ON: ENTER switch on
      		-
      Steering Wheel Up Switch
      		UP/DOWN UP switch/OFF or ON
      		OFF: UP/DOWN UP switch off
      		-
      ON: UP/DOWN UP switch on
      Steering Wheel Down Switch
      		UP/DOWN DOWN switch/OFF or ON
      		OFF: UP/DOWN DOWN switch off
      		-
      ON: UP/DOWN DOWN switch on


ACTIVE TEST
Using the GTS to perform Active Tests allows relays, VSVs, actuators and other items to be operated without removing any parts. This non-intrusive functional inspection can be very useful because intermittent operation may be discovered before parts or wiring is disturbed. Performing Active Tests early in troubleshooting is one way to save diagnostic time. Data List information can be displayed while performing Active Tests.

  1. Turn the ignition switch to off.

  2. Connect the GTS to the DLC3.

  3. Turn the ignition switch to ON.

  4. Turn the GTS on.

  5. Enter the following menus: Body Electrical / Combination Meter / Active Test.

  6. Check the operation by referring to the table below.

    Combination Meter
    Tester Display
    		Test Part
    		Control Range
    		Diagnostic Note
    Speed Meter Operation
    		Speedometer
    1. OFF, 0, 40, 80, 120, 160 or 200 (km/h) (for km/h)
    2. OFF, 0, 40, 80 or 120 (mph) (for mph)
    		There is a deviation in the values displayed on the speedometer display (Control range → Speedometer)
    for km/h (except Australia):
    1. 40 → 41.7 to 46.2
    2. 80 → 83.4 to 88.4
    3. 120 → 125.1 to 130.6
    4. 160 → 166.2 to 173.2
    for km/h (for Australia):
    1. 40 → 40.8 to 45.3
    2. 80 → 81.6 to 86.6
    3. 120 → 122.4 to 127.4
    4. 160 → 163.2 to 168.2
    for mph:
    1. 40 → 42 to 44.5
    2. 80 → 83.1 to 87.1
    Tacho Meter Operation
    		Tachometer
    		OFF, 0, 1000, 2000, 3000, 4000, 5000, 6000 or 7000*1 (rpm)
    		-
    Fuel Meter Operation
    		Fuel receiver gauge
    		OFF, Sender, Empty, Warning, 1/4, 1/2, 3/4, Full, Sender F
    		-
    A/T Indicator Operation 1*2
    		Shift indicator
    		OFF, L, 2, 3, 4, D, N, R, P
    		-
    A/T Indicator Operation 2*2
    		Shift indicator
    		OFF, 5, 6*3 or S
    		-
    Meter Display 1
    		Multi-information display
    		OFF or All
    		-
    Meter Display 2*4
    		Multi-information display
    		OFF, 9, 8 or 7
    		-
    Indicat. Lamp Beam
    		High beam indicator light
    		OFF or ON
    		-
    Indicat. Lamp Tail
    		Tail indicator light
    		OFF or ON
    		-
    Indicat. Lamp Fr FOG*5
    		Front fog indicator light
    		OFF or ON
    		-
    Indicat. Lamp Rr FOG*6
    		Rear fog indicator light
    		OFF or ON
    		-
    Indicat. Lamp Airbag
    		SRS warning light
    		OFF or ON
    		-
    Indicat. Precrash*7
    		Pre-crash warning light
    		OFF or ON
    		-
    Driver Side Seat Belt
    		Driver side seat belt warning light
    		OFF or ON
    		-
    Indicat. Lamp Doors All Open
    		Door indicator light
    		OFF or ON
    		-
    Indicat. Lamp Fuel
    		Fuel level warning light
    		OFF or ON
    		-
    Indicat. Lamp Water*4, *29
    		Water level warning light
    		OFF or ON
    		-
    Indicat. Headlamp Auto Leveling*27
    		Headlight beam level control system warning light
    		OFF or ON
    		-
    Indicat. Lamp Charge*10, *33
    		Charge warning light
    		OFF or ON
    		-
    Indicat. Lamp ABS
    		ABS warning light
    		OFF or ON
    		-
    Indicat. Lamp Slip*8
    		Slip indicator light
    		OFF or ON
    		-
    VSC TRC Indicator*8
    		VSC TRC indicator light
    		OFF or ON
    		-
    Indicat. Lamp Brake
    		Brake warning light
    		OFF or ON
    		-
    Indicat. Oil Pressure*4
    		Oil pressure warning light
    		OFF or ON
    		-
    Indicat. Lamp Oil Level*4, *9, *10, *11
    		Oil level warning light
    		OFF or ON
    		-
    Indicat. GLOW*12
    		GLOW indicator light
    		OFF or ON
    		-
    Indicat. ECONO*2
    		Eco driving indicator light
    		OFF or ON
    		-
    A/T OIL Temperature Operation*2, *4
    		A/T oil temperature warning light
    		OFF or ON
    		-
    Indicat. Lamp Cruise*13
    		Cruise main indicator light (green)
    		OFF or ON
    		-
    Indicat. KEY*4, *14
    		Key Warning light
    		OFF or ON
    		-
    Maintenance Indicator*4, *9, *15
    		Oil Maintenance indicator light
    		OFF or ON
    		-
    Indicat. Timing Belt*4, *9, *10, *16
    		Timing belt interval indicator light
    		OFF or ON
    		-
    Indicat. Over Speed*17
    		Over speed warning light
    		OFF or ON
    		-
    Master Warning*18
    		Master warning light
    		OFF or ON
    		-
    Indicat. Clearance Sonar*19, *36
    		Clearance sonar indicator light
    		OFF or ON
    		-
    Indicat. Downhill Assist Control*20
    		Downhill assist control indicator light
    		OFF or ON
    		-
    Indicat. 2nd START*2
    		2nd START indicator light
    		OFF or ON
    		-
    Indicat. Ctr DIFF LOCK
    		Center differential lock indicator light
    		OFF or ON
    		-
    Indicat. Rr DIFF LOCK*30
    		Rear differential lock indicator light
    		OFF or ON
    		-
    Indicat. 4LO
    		4LO indicator light
    		ON or OFF
    		-
    Indicat. CRAWL*21
    		CRAWL indicator light
    		ON or OFF
    		-
    Indicat. SIL (Up)*15, *22
    		SIL (Up) indicator light
    		ON or OFF
    		-
    Indicat. SIL (Down)*15, *22
    		SIL (Down) indicator light
    		ON or OFF
    		-
    Indicat. Radar Cruise*31
    		Radar cruise indicator light
    		ON or OFF
    		-
    Indicat. SET*13
    		SET indicator light
    		OFF or ON
    		-
    Indicat. VSC OFF*8
    		VSC OFF indicator light
    		OFF or ON
    		-
    Fuel Filter Indicator*37
    		Fuel filter indicator light
    		OFF or ON
    		-
    KDSS Indicator*23
    		Kinetic dynamic suspension system indicator light
    		OFF or ON
    		-
    OFF Road Guidance Indicator*24
    		Multi-terrain select indicator light
    		OFF or ON
    		-
    PPS Indicator*8, *25
    		PPS warning light
    		OFF or ON
    		-
    Cruise Indicator*13
    		Cruise main indicator light (yellow)
    		OFF or ON
    		-
    Water Temperature Meter Operation
    		Engine coolant temperature receiver gauge
    		OFF, 45, 60, 70, 80, Middle, 110, 120, 127
    		-
    Blind Spot Monitor Indicator*26
    		BSM indicator light
    		OFF or ON
    		-
    Check Engine Indicator*33
    		MIL
    		OFF or ON
    		-
    LED Head Lamp Warning*27
    		LED headlight warning light
    		OFF or ON
    		-
    Indicat. Tire Pressure Warning System*28
    		Tire pressure warning light
    		OFF or ON
    		-
    Diesel Particulate Filter Warning*32
    		Diesel particulate filter warning light
    		OFF or ON
    		-
    Reductant Warning Indicator*34
    		Reductant warning indicator
    		OFF or ON
    		-
    Indicat. Lamp Water Level*35
    		SEDIMENT warning light
    		OFF or ON
    		-

    1. *1: for 1GR-FE, 2TR-FE
    2. *2: for Automatic Transmission
    3. *3: for Automatic Transmission (AC60F)
    4. *4: for Analog Meter, Segment Display Type
    5. *5: w/ Front Fog Light
    6. *6: w/ Rear Fog Light
    7. *7: w/ Pre-crash Safety System
    8. *8: w/ VSC
    9. *9: for 1KD-FTV
    10. *10: for 1GD-FTV
    11. *11: for 1GR-FE, Europe
    12. *12: for Diesel Engine
    13. *13: w/ Cruise Control System
    14. *14: w/ Entry and Start System
    15. *15: for Europe
    16. *16: for 5L-E
    17. *17: for Middle East
    18. *18: except Analog Meter, Segment Display Type
    19. *19: w/ TOYOTA Parking Assist-sensor System
    20. *20: w/ Downhill Assist Control
    21. *21: w/ Crawl Control
    22. *22: for Manual Transmission
    23. *23: w/ Kinetic Dynamic Suspension System
    24. *24: w/ Multi Function Switch
    25. *25: w/ Power Steering System
    26. *26: w/ Blind Spot Monitor System
    27. *27: for LED Headlight
    28. *28: w/ Tire Pressure Monitor System
    29. *29: w/ Washer Fluid Level Warning System
    30. *30: w/ Rear Differential Lock
    31. *31: w/ Dynamic Radar Cruise Control System
    32. *32: w/ DPF
    33. *33: for 2TR-FE
    34. *34: w/ Urea SCR System
    35. *35: w/ SEDIMENT Warning Light
    36. *36: for Optitron Meter
    37. *37: w/ SEDIMENT/FILTER Warning Light