Land Cruiser URJ200 URJ202 GRJ200 VDJ200 - 1VD-FTV ENGINE CONTROL

DESCRIPTION

MONITOR DESCRIPTION

WIRING DIAGRAM

INSPECTION PROCEDURE

CHECK HARNESS AND CONNECTOR (POWER SOURCE)

INSPECT EGR VALVE ASSEMBLY (No. 1 or No. 2) (POSITION SENSOR)

CHECK HARNESS AND CONNECTOR (EGR VALVE POSITION SENSOR - ECM)

REPLACE ECM

REPLACE EGR VALVE ASSEMBLY (No. 1 or No. 2)

REPAIR OR REPLACE HARNESS OR CONNECTOR

CONFIRM WHETHER MALFUNCTION HAS BEEN SUCCESSFULLY REPAIRED

DTC P0405 Exhaust Gas Recirculation Sensor "A" Circuit Low

DTC P0406 Exhaust Gas Recirculation Sensor "A" Circuit High

DTC P0407 Exhaust Gas Recirculation Sensor "B" Circuit Low

DTC P0408 Exhaust Gas Recirculation Sensor "B" Circuit High

DESCRIPTION

The EGR valve position sensor is mounted on the EGR valve and used for detecting the lift amount of the valve. The lift amount detected by the sensor is provided to the ECM as feedback. The ECM then regulates the lift amount of the valve in accordance with engine running conditions.

P0405
DTC Detection Drive PatternDTC Detection ConditionTrouble Area
Ignition switch ON for 5 secondsNo. 1 EGR valve position sensor output voltage is less than 0.1 V for 5 seconds (1 trip detection logic).
Open in No. 1 EGR valve position sensor circuit
No. 1 EGR valve (EGR valve position sensor)
ECM
P0406
DTC Detection Drive PatternDTC Detection ConditionTrouble Area
Ignition switch ON for 5 secondsNo. 1 EGR valve position sensor output voltage is more than 4.9 V for 5 seconds (1 trip detection logic).
Short in No. 1 EGR valve position sensor circuit
No. 1 EGR valve (EGR valve position sensor)
ECM
P0407
DTC Detection Drive PatternDTC Detection ConditionTrouble Area
Ignition switch ON for 5 secondsNo. 2 EGR valve position sensor output voltage is less than 0.1 V for 5 seconds (1 trip detection logic).
Open in No. 2 EGR valve position sensor circuit
No. 2 EGR valve (EGR valve position sensor)
ECM
P0408
DTC Detection Drive PatternDTC Detection ConditionTrouble Area
Ignition switch ON for 5 secondsNo. 2 EGR valve position sensor output voltage is more than 4.9 V for 5 seconds (1 trip detection logic).
Short in No. 2 EGR valve position sensor circuit
No. 2 EGR valve (EGR valve position sensor)
ECM

MONITOR DESCRIPTION

When the output voltage of the EGR valve position sensor deviates from the normal operating range of 0.1 to 4.9 V for more than 5 seconds, the ECM interprets this as a malfunction of the sensor circuit, and illuminates the MIL.


WIRING DIAGRAM

Refer to DTC P0400 ().


INSPECTION PROCEDURE

  • NOTICE:
  • After replacing the ECM, the new ECM needs registration () and initialization ().
  • HINT:
Read freeze frame data using the intelligent tester. Freeze frame data records the engine condition when malfunctions are detected. When troubleshooting, freeze frame data can help determine if the vehicle was moving or stationary, if the engine was warmed up or not, and other data from the time the malfunction occurred.
Data List items "EGR Lift Sensor Volt %" and "EGR Lift Sensor Volt % #2" are values calculated by converting the EGR position sensor output voltage of 0 to 5 V to a percentage from 0 to 100%.
1.CHECK HARNESS AND CONNECTOR (POWER SOURCE)
Dtc P0405  Exhaust Gas Recirculation Sensor A Circuit Low. 1VD-FTV ENGINE CONTROL. Land Cruiser URJ200  URJ202 GRJ200 VDJ200

Disconnect the EGR valve connector.

Measure the voltage according to the value(s) in the table below.

  • Standard Voltage:
  • No. 1
    Tester ConnectionSwitch ConditionSpecified Condition
    C87-3 (VC) - C87-2 (E2)Ignition switch ON4.5 to 5.5 V
  • No. 2
    Tester ConnectionSwitch ConditionSpecified Condition
    C88-3 (VC) - C88-2 (E2)Ignition switch ON4.5 to 5.5 V
NG
Go to step 3
OK
2.INSPECT EGR VALVE ASSEMBLY (No. 1 or No. 2) (POSITION SENSOR)
Dtc P0405  Exhaust Gas Recirculation Sensor A Circuit Low. 1VD-FTV ENGINE CONTROL. Land Cruiser URJ200  URJ202 GRJ200 VDJ200

Disconnect the EGR valve connector.

Measure the resistance according to the value(s) in the table below.

  • Standard Resistance:
  • No. 1
    Tester ConnectionConditionSpecified Condition
    3 (VC) - 2 (E2)20°C (68°F)2.45 to 4.55 kΩ
    4 (EGLS) - 2 (E2)20°C (68°F)2.45 to 4.55 kΩ
  • No. 2
    Tester ConnectionConditionSpecified Condition
    3 (VC) - 2 (E2)20°C (68°F)2.45 to 4.55 kΩ
    4 (EGS2) - 2 (E2)20°C (68°F)2.45 to 4.55 kΩ
NG
Go to step 5
OK
3.CHECK HARNESS AND CONNECTOR (EGR VALVE POSITION SENSOR - ECM)
Dtc P0405  Exhaust Gas Recirculation Sensor A Circuit Low. 1VD-FTV ENGINE CONTROL. Land Cruiser URJ200  URJ202 GRJ200 VDJ200

Disconnect the EGR valve connector.

Disconnect the ECM connector.

Measure the resistance according to the value(s) in the table below.

  • Standard Resistance (Check for Open):
  • No. 1 (LHD)
    Tester ConnectionConditionSpecified Condition
    C87-3 (VC) - C45-90 (VCEG)AlwaysBelow 1 Ω
    C87-4 (EGLS) - C45-89 (EGLS)AlwaysBelow 1 Ω
    C87-2 (E2) - C45-87 (EEGL)AlwaysBelow 1 Ω
  • No. 2 (LHD)
    Tester ConnectionConditionSpecified Condition
    C88-3 (VC) - C45-90 (VCEG)AlwaysBelow 1 Ω
    C88-4 (EGS2) - C45-88 (EGS2)AlwaysBelow 1 Ω
    C88-2 (E2) - C45-87 (EEGL)AlwaysBelow 1 Ω
  • No. 1 (RHD)
    Tester ConnectionConditionSpecified Condition
    C87-3 (VC) - C46-90 (VCEG)AlwaysBelow 1 Ω
    C87-4 (EGLS) - C46-89 (EGLS)AlwaysBelow 1 Ω
    C87-2 (E2) - C46-87 (EEGL)AlwaysBelow 1 Ω
  • No. 2 (RHD)
    Tester ConnectionConditionSpecified Condition
    C88-3 (VC) - C46-90 (VCEG)AlwaysBelow 1 Ω
    C88-4 (EGS2) - C46-88 (EGS2)AlwaysBelow 1 Ω
    C88-2 (E2) - C46-87 (EEGL)AlwaysBelow 1 Ω
  • Standard Resistance (Check for Short):
  • No. 1 (LHD)
    Tester ConnectionConditionSpecified Condition
    C87-3 (VC) or C45-90 (VCEG) - Body groundAlways10 kΩ or higher
    C87-4 (EGLS) or C45-89 (EGLS) - Body groundAlways10 kΩ or higher
  • No. 2 (LHD)
    Tester ConnectionConditionSpecified Condition
    C88-3 (VC) or C45-90 (VCEG) - Body groundAlways10 kΩ or higher
    C88-4 (EGS2) or C45-88 (EGS2) - Body groundAlways10 kΩ or higher
  • No. 1 (RHD)
    Tester ConnectionConditionSpecified Condition
    C87-3 (VC) or C46-90 (VCEG) - Body groundAlways10 kΩ or higher
    C87-4 (EGLS) or C46-89 (EGLS) - Body groundAlways10 kΩ or higher
  • No. 2 (RHD)
    Tester ConnectionConditionSpecified Condition
    C88-3 (VC) or C46-90 (VCEG) - Body groundAlways10 kΩ or higher
    C88-4 (EGS2) or C46-88 (EGS2) - Body groundAlways10 kΩ or higher
NG
Go to step 6
OK
4.REPLACE ECM

Replace the ECM ().

NEXT
Go to step 7
5.REPLACE EGR VALVE ASSEMBLY (No. 1 or No. 2)

Replace the EGR valve assembly (No. 1 or No. 2) ().

NEXT
Go to step 7
6.REPAIR OR REPLACE HARNESS OR CONNECTOR
NEXT
7.CONFIRM WHETHER MALFUNCTION HAS BEEN SUCCESSFULLY REPAIRED

Connect the intelligent tester to the DLC3.

Clear the DTCs ().

Turn the ignition switch off.

Turn the ignition switch to ON for 5 seconds.

Enter the following menus: Powertrain / Engine / DTC.

Confirm that the DTC is not output again.

NEXT
END