Brand:
Toyota
Model Name:
Camry ACV40 GSV40
Manual:
Repair Manual
Section:
2Az-Fe Engine Control System
Title:
Sfi System
- HINT:
- Parameters listed in the chart may be different than your readings depending on the type of instrument and other factors.
- If any DTCs are displayed during a check mode DTC check, check the circuit for the DTCs listed in the table below. For details of each DTC, refer to the page indicated.
| DTC Code | Detection Item | Trouble Area | MIL | Memory | See page |
| P0010 | Camshaft Position "A" Actuator Circuit (Bank 1) | 1. Open or short in camshaft timing oil control valve assembly circuit 2. Camshaft timing oil control valve assembly 3. ECM | Comes on | DTC stored | Click here |
| P0011 | Camshaft Position "A" - Timing Over-Advanced or System Performance (Bank 1) | 1. Valve timing 2. Camshaft timing oil control valve assembly 3. Oil control valve filter 4. Camshaft timing gear assembly 5. ECM | Comes on*1/Does not come on*2 | DTC stored | Click here |
| P0012 | Camshaft Position "A" - Timing Over-Retarded (Bank 1) | 1. Valve timing 2. Camshaft timing oil control valve assembly 3. Oil control valve filter 4. Camshaft timing gear assembly 5. ECM | Comes on*1/Does not come on*2 | DTC stored | Click here |
| P0016 | Crankshaft Position - Camshaft Position Correlation (Bank 1 Sensor A) | 1. Valve timing 2. Camshaft timing oil control valve assembly 3. Oil control valve filter 4. Camshaft timing gear assembly 5. ECM | Comes on*1/Does not come on*2 | DTC stored | Click here |
| P0031 | Oxygen (A/F) Sensor Heater Control Circuit Low (Bank 1 Sensor 1) | 1. Open in air fuel ratio sensor heater (sensor 1) circuit 2. Air fuel ratio sensor heater (sensor 1) 3. ECM | Comes on | DTC stored | Click here |
| P0032 | Oxygen (A/F) Sensor Heater Control Circuit High (Bank 1 Sensor 1) | 1. Short in air fuel ratio sensor heater (sensor 1) circuit 2. Air fuel ratio sensor heater (sensor 1) 3. ECM | Comes on | DTC stored | Click here |
| P0037 | Oxygen Sensor Heater Control Circuit Low (Bank 1 Sensor 2) | 1. Open in heated oxygen sensor heater (sensor 2) circuit 2. Heated oxygen sensor heater (sensor 2) 3. ECM | Comes on | DTC stored | Click here |
| P0038 | Oxygen Sensor Heater Control Circuit High (Bank 1 Sensor 2) | 1. Short in heated oxygen sensor heater (sensor 2) circuit 2. Heated oxygen sensor heater (sensor 2) 3. ECM | Comes on | DTC stored | Click here |
| P0100 *2 | Mass or Volume Air Flow Circuit | 1. Open or short in mass air flow meter sub-assembly circuit 2. Mass air flow meter sub-assembly 3. ECM | Comes on | DTC stored | Click here |
| P0102 | Mass or Volume Air Flow Circuit Low Input | 1. Open or short in mass air flow meter sub-assembly circuit 2. Mass air flow meter sub-assembly 3. ECM | Comes on | DTC stored | Click here |
| P0103 | Mass or Volume Air Flow Circuit High Input | 1. Open or short in mass air flow meter sub-assembly circuit 2. Mass air flow meter sub-assembly 3. ECM | Comes on | DTC stored | Click here |
| P0110 *2 | Intake Air Temperature Circuit Malfunction | 1. Open or short in intake air temperature sensor circuit 2. Intake air temperature sensor (built into mass air flow meter sub-assembly) 3. ECM | Comes on | DTC stored | Click here |
| P0112 | Intake Air Temperature Circuit Low Input | 1. Short in intake air temperature sensor circuit 2. Intake air temperature sensor (built into mass air flow meter sub-assembly) 3. ECM | Comes on | DTC stored | Click here |
| P0113 | Intake Air Temperature Circuit High Input | 1. Open in intake air temperature sensor circuit 2. Intake air temperature sensor (built into mass air flow meter sub-assembly) 3. ECM | Comes on | DTC stored | Click here |
| P0115 | Engine Coolant Temperature Circuit Malfunction | 1. Open or short in engine coolant temperature sensor circuit 2. Engine coolant temperature sensor 3. ECM | Comes on | DTC stored | Click here |
| P0116 | Engine Coolant Temperature Circuit Range / Performance Problem | 1. Thermostat 2. Engine coolant temperature sensor | Comes on | DTC stored | Click here |
| P0117 | Engine Coolant Temperature Circuit Low Input | 1. Short in engine coolant temperature sensor circuit 2. Engine coolant temperature sensor 3. ECM | Comes on | DTC stored | Click here |
| P0118 | Engine Coolant Temperature Circuit High Input | 1. Open in engine coolant temperature sensor circuit 2. Engine coolant temperature sensor 3. ECM | Comes on | DTC stored | Click here |
| P0120 | Throttle / Pedal Position Sensor / Switch "A" Circuit Malfunction | 1. Throttle position sensor (built into throttle with motor body assembly) 2. ECM | Comes on | DTC stored | Click here |
| P0121 | Throttle / Pedal Position Sensor / Switch "A" Circuit Range / Performance Problem | 1. Throttle position sensor (built into throttle with motor body assembly) 2. Throttle position sensor circuit 3. ECM | Comes on | DTC stored | Click here |
| P0122 | Throttle / Pedal Position Sensor / Switch "A" Circuit Low Input | 1. Throttle position sensor (built into throttle with motor body assembly) 2. Short in VTA1 circuit 3. Open in VC circuit 4. ECM | Comes on | DTC stored | Click here |
| P0123 | Throttle / Pedal Position Sensor / Switch "A" Circuit High Input | 1. Throttle position sensor (built into throttle with motor body assembly) 2. Open in VTA1 circuit 3. Open in E2 circuit 4. Short between VC and VTA1 circuits 5. ECM | Comes on | DTC stored | Click here |
| P0136 *1 | Oxygen Sensor Circuit Malfunction (Bank 1 Sensor 2) | 1. Open or short in heated oxygen sensor (bank 1 sensor 2) circuit 2. Heated oxygen sensor (bank 1 sensor 2) 3. Heated oxygen sensor heater (bank 1 sensor 2) 4. Air fuel ratio sensor (bank 1 sensor 1) 5. Gas leaks from exhaust system | Comes on | DTC stored | Click here |
| P0137 | Oxygen Sensor Circuit Low Voltage (Bank 1 Sensor 2) | 1. Open in heated oxygen sensor (bank 1 sensor 2) circuit 2. Heated oxygen sensor (bank 1 sensor 2) 3. Heated oxygen sensor heater (bank 1 sensor 2) 4. Air fuel ratio sensor (bank 1 sensor 1) 5. Gas leaks from exhaust system | Comes on | DTC stored | Click here |
| P0138 *1 | Oxygen Sensor Circuit High Voltage (Bank 1 Sensor 2) | 1. Short in heated oxygen sensor (bank 1 sensor 2) circuit 2. Heated oxygen sensor (bank 1 sensor 2) 3. Air fuel ratio sensor (bank 1 sensor 1) 4. ECM | Comes on | DTC stored | Click here |
| P0171 *1 | System Too Lean (Bank 1) | 1. Intake system 2. Fuel injector assembly 3. Mass air flow meter 4. Engine coolant temperature sensor 5. Fuel pressure 6. Gas leaks from exhaust system 7. Open or short in air fuel ratio sensor (bank 1 sensor 1) circuit 8. Air fuel ratio sensor (bank 1 sensor 1) 9. Air fuel ratio sensor heater (bank 1 sensor 1) 10. Air fuel ratio sensor heater circuit (bank 1 sensor 1) 11. PCV valve and hose 12. PCV hose connections 13. ECM 14. Wire harness or connector | Comes on | DTC stored | Click here |
| P0172 *1 | System Too Rich (Bank 1) | 1. Fuel injector assembly 2. Mass air flow meter 3. Engine coolant temperature sensor 4. Ignition system 5. Fuel pressure 6. Gas leaks from exhaust system 7. Open or short in air fuel ratio sensor (bank 1 sensor 1) circuit 8. Air fuel ratio sensor (bank 1 sensor 1) 9. Air fuel ratio sensor heater (bank 1 sensor 1) 10. Air fuel ratio sensor heater circuit (bank 1 sensor 1) 11. Wire harness or connector 12. ECM | Comes on | DTC stored | Click here |
| P0220 | Throttle / Pedal Position Sensor / Switch "B" Circuit | 1. Throttle position sensor (built into throttle with motor body assembly) 2. ECM | Comes on | DTC stored | Click here |
| P0222 | Throttle / Pedal Position Sensor / Switch "B" Circuit Low Input | 1. Throttle position sensor (built into throttle with motor body assembly) 2. Short in VTA2 circuit 3. Open in VC circuit 4. ECM | Comes on | DTC stored | Click here |
| P0223 | Throttle / Pedal Position Sensor / Switch "B" Circuit High Input | 1. Throttle position sensor (built into throttle with motor body assembly) 2. Open in VTA2 circuit 3. Open in E2 circuit 4. Short between VC and VTA2 circuits 5. ECM | Comes on | DTC stored | Click here |
| P0300 *1 | Random / Multiple Cylinder Misfire Detected | 1. Open or short in engine wire harness 2. Connector connections 3. Vacuum hose connections 4. Ignition system 5. Fuel injector assembly 6. Fuel pressure 7. Fuel line 8. Fuel pump assembly 9. Mass air flow meter 10. Engine coolant temperature sensor 11. Compression pressure 12. Valve clearance 13. Valve timing 14. PCV valve and hose 15. PCV hose connections 16. Intake system 17. ECM | Comes on/Blinks*3 | DTC stored | Click here |
| P0301 *1 | Cylinder 1 Misfire Detected | Same as DTC P0300 | Comes on/Blinks*3 | DTC stored | Click here |
| P0302 *1 | Cylinder 2 Misfire Detected | Same as DTC P0300 | Comes on/Blinks*3 | DTC stored | Click here |
| P0303 *1 | Cylinder 3 Misfire Detected | Same as DTC P0300 | Comes on/Blinks*3 | DTC stored | Click here |
| P0304 *1 | Cylinder 4 Misfire Detected | Same as DTC P0300 | Comes on/Blinks*3 | DTC stored | Click here |
| P0327 | Knock Sensor 1 Circuit Low Input (Bank 1 or Single Sensor) | 1. Short in knock control sensor circuit 2. Knock control sensor 3. ECM | Comes on | DTC stored | Click here |
| P0328 | Knock Sensor 1 Circuit High Input (Bank 1 or Single Sensor) | 1. Open in knock control sensor circuit 2. Knock control sensor 3. ECM | Comes on | DTC stored | Click here |
| P0335 | Crankshaft Position Sensor "A" Circuit | 1. Open or short in crankshaft position sensor circuit 2. Crankshaft position sensor 3. Crankshaft position sensor plate 4. ECM | Comes on | DTC stored | Click here |
| P0339 | Crankshaft Position Sensor "A" Circuit Intermittent | 1. Open or short in crankshaft position sensor circuit 2. Crankshaft position sensor 3. Crankshaft position sensor plate 4. ECM | Does not come on | DTC stored | Click here |
| P0340 | Camshaft Position Sensor "A" Circuit (Bank 1 or Single Sensor) | 1. Open or short in camshaft position sensor circuit 2. Camshaft position sensor 3. Camshaft 4. Timing chain jumped a tooth 5. ECM | Comes on | DTC stored | Click here |
| P0351 | Ignition Coil "A" Primary / Secondary Circuit | 1. Ignition system 2. Open or short in IGF1 or IGT1 circuit between ignition coil assembly and ECM 3. No. 1 ignition coil assembly 4. ECM | Comes on | DTC stored | Click here |
| P0352 | Ignition Coil "B" Primary / Secondary Circuit | 1. Ignition system 2. Open or short in IGF1 or IGT2 circuit between ignition coil assembly and ECM 3. No. 2 ignition coil assembly 4. ECM | Comes on | DTC stored | Click here |
| P0353 | Ignition Coil "C" Primary / Secondary Circuit | 1. Ignition system 2. Open or short in IGF1 or IGT3 circuit between ignition coil assembly and ECM 3. No. 3 ignition coil assembly 4. ECM | Comes on | DTC stored | Click here |
| P0354 | Ignition Coil "D" Primary / Secondary Circuit | 1. Ignition system 2. Open or short in IGF1 or IGT4 circuit between ignition coil assembly and ECM 3. No. 4 ignition coil assembly 4. ECM | Comes on | DTC stored | Click here |
| P0420 *1 | Catalyst System Efficiency Below Threshold (Bank 1) | 1. Gas leak from exhaust system 2. Air fuel ratio sensor (sensor 1) 3. Heated oxygen sensor (sensor 2) 4. Exhaust manifold converter sub-assembly (TWC: Front catalyst) 5. Front exhaust pipe assembly (TWC: Rear catalyst) | Comes on | DTC stored | Click here |
| P0443 | Evaporative Emission Control System Purge Control Valve Circuit | 1. Open or short in purge VSV circuit 2. Purge VSV 3. ECM | Comes on | DTC stored | Click here |
| P0500 | Vehicle Speed Sensor "A" | 1. Open or short in stop light switch signal circuit 2. Stop light switch assembly 3. STOP fuse 4. ECM | Comes on | DTC stored | Click here |
| P0504 | Brake Switch "A" / "B" Correlation | 1. Open or short in stop light switch signal circuit 2. Stop light switch assembly 3. STOP fuse 4. ECM | Does not come on | DTC stored | Click here |
| P0505 *1 | Idle Control System Malfunction | 1. Electronic throttle control system 2. Intake system 3. PCV hose connections 4. ECM | Comes on | DTC stored | Click here |
| P0560 | System Voltage | 1. Open in back up power source circuit 2. Battery 3. Battery terminals 4. ECM | Comes on | DTC stored | Click here |
| P0604 | Internal Control Module Random Access Memory (RAM) Error | ECM | Comes on | DTC stored | Click here |
| P0606 | ECM / PCM Processor | ECM | Comes on | DTC stored | Click here |
| P0607 *2 | Control Module Performance | ECM | Comes on | DTC stored | Click here |
| P060A | Internal Control Module Monitoring Processor Performance | ECM | Comes on | DTC stored | Click here |
| P060D | Internal Control Module Accelerator Pedal Position Performance | ECM | Comes on | DTC stored | Click here |
| P060E | Internal Control Module Throttle Position Performance | ECM | Comes on | DTC stored | Click here |
| P0617 | Starter Relay Circuit High | 1. Short in starter signal circuit 2. Park/neutral position switch 3. Ignition switch assembly 4. ECM | Comes on | DTC stored | Click here |
| P0657 | Actuator Supply Voltage Circuit / Open | ECM | Comes on | DTC stored | Click here |
| P0724 | Brake Switch "B" Circuit High | 1. Short in stop light switch assembly signal circuit 2. Stop light switch assembly 3. ECM | Comes on | DTC stored | Click here |
| P1603 *4 | Engine Stall History | 1. Air leak in intake system 2. Purge VSV 3. Brake booster hose not connected properly 4. Mass air flow meter sub-assembly 5. Engine coolant temperature sensor 6. Wire harness or connector 7. Air fuel ratio sensor 8. Power supply circuit (purge VSV, fuel injector assembly, ignition coil assembly) 9. Fuel pump 10. Fuel pump control system 11. Fuel line 12. Throttle body assembly 13. Camshaft timing oil control valve assembly 14. VVT system 15. Air conditioning system 16. Power steering system 17. Electrical load signal system 18. A/T system 19. Park/neutral position switch 20. ECM | Does not come on | DTC stored | Click here |
| P1604 *1 | Startability Malfunction | 1. Engine assembly (excess friction, compression loss) 2. Starter 3. Crankshaft position sensor 4. Camshaft position sensor 5. Engine coolant temperature sensor 6. Fuel pump 7. Fuel pump control system 8. Fuel line (fuel filter, pipes and hoses) 9. Fuel injector 10. Throttle body 11. Fuel pressure regulator 12. Battery 13. Drive plate 14. Flywheel 15. Spark plug 16. Ignition coil circuit 17. Intake system 18. Camshaft timing oil control valve 19. Mass air flow meter 20. Air fuel ratio sensor 21. Valve timing 22. Fuel 23. Purge VSV 24. Intake valve 25. Immobiliser system 26. ECM | Does not come on | DTC stored | Click here |
| P1605 *1 | Rough Idling | 1. Air leak in intake system 2. Purge VSV 3. Brake booster hose not connected properly 4. Mass air flow meter sub-assembly 5. Engine coolant temperature sensor 6. Wire harness or connector 7. Air fuel ratio sensor 8. Power supply circuit (purge VSV, fuel injector assembly, ignition coil) 9. Fuel pump 10. Fuel pump control system 11. Fuel line 12. Throttle body assembly 13. Camshaft timing oil control valve assembly 14. VVT system 15. Knock control sensor 16. Ignition coil 17. Fuel injector assembly 18. Spark plug(s) 19. Air conditioning system 20. Power steering system 21. Electrical load signal system 22. A/T system 23. Park/neutral position switch 24. ECM | Does not come on | DTC stored | Click here |
| P1607 | Cruise Control Input Processor | ECM | Comes on | DTC stored | Click here |
| P2102 | Throttle Actuator Control Motor Circuit Low | 1. Open in throttle actuator circuit 2. Throttle actuator 3. ECM | Comes on | DTC stored | Click here |
| P2103 | Throttle Actuator Control Motor Circuit High | 1. Short in throttle actuator circuit 2. Throttle actuator 3. Throttle valve 4. Throttle body assembly 5. ECM | Comes on | DTC stored | Click here |
| P2109 *1 | Throttle / Pedal Position Sensor "A" Minimum Stop Performance | Throttle body assembly | Does not come on | DTC stored | Click here |
| P2111 | Throttle Actuator Control System - Stuck Open | 1. Throttle actuator 2. Throttle body assembly 3. Throttle valve 4. ECM 5. Wire harness or connector | Comes on | DTC stored | Click here |
| P2112 | Throttle Actuator Control System - Stuck Closed | 1. Throttle actuator 2. Throttle body assembly 3. Throttle valve 4. ECM 5. Wire harness or connector | Comes on | DTC stored | Click here |
| P2118 | Throttle Actuator Control Motor Current Range / Performance | 1. Open in electronic throttle control system power source circuit 2. Battery 3. Battery terminals 4. ETCS fuse 5. ECM | Comes on | DTC stored | Click here |
| P2119 | Throttle Actuator Control Throttle Body Range / Performance | 1. Electronic throttle control system 2. ECM 3. Wire harness or connector | Comes on | DTC stored | Click here |
| P2120 | Throttle / Pedal Position Sensor / Switch "D" Circuit | 1. Accelerator pedal position sensor 2. ECM | Comes on | DTC stored | Click here |
| P2121 | Throttle / Pedal Position Sensor / Switch "D" Circuit Range / Performance | 1. Accelerator pedal position sensor 2. ECM | Comes on | DTC stored | Click here |
| P2122 | Throttle / Pedal Position Sensor / Switch "D" Circuit Low Input | 1. Accelerator pedal position sensor 2. Open in VCP1 circuit 3. Open or ground short in VPA circuit 4. ECM | Comes on | DTC stored | Click here |
| P2123 | Throttle / Pedal Position Sensor / Switch "D" Circuit High Input | 1. Accelerator pedal position sensor 2. Open in EPA circuit 3. ECM | Comes on | DTC stored | Click here |
| P2125 | Throttle / Pedal Position Sensor / Switch "E" Circuit | 1. Accelerator pedal position sensor 2. ECM | Comes on | DTC stored | Click here |
| P2127 | Throttle / Pedal Position Sensor / Switch "E" Circuit Low Input | 1. Accelerator pedal position sensor 2. Open in VCP2 circuit 3. Open or ground short in VPA2 circuit 4. ECM | Comes on | DTC stored | Click here |
| P2128 | Throttle / Pedal Position Sensor / Switch "E" Circuit High Input | 1. Accelerator pedal position sensor 2. Open in EPA2 circuit 3. ECM | Comes on | DTC stored | Click here |
| P2135 | Throttle / Pedal Position Sensor / Switch "A" / "B" Voltage Correlation | 1. Short between VTA1 and VTA2 circuits 2. Throttle position sensor (built into throttle with motor body assembly) 3. ECM | Comes on | DTC stored | Click here |
| P2138 | Throttle / Pedal Position Sensor / Switch "D" / "E" Voltage Correlation | 1. Short between VPA and VPA2 circuits 2. Accelerator pedal position sensor 3. ECM | Comes on | DTC stored | Click here |
| P2195 *1 | Oxygen (A/F) Sensor Signal Stuck Lean (Bank 1 Sensor 1) | 1. Open or short in air fuel ratio sensor (bank 1 sensor 1) circuit 2. Air fuel ratio sensor (bank 1 sensor 1) 3. Air fuel ratio sensor heater (bank 1 sensor 1) 4. Air fuel ratio sensor heater circuit 5. Intake system 6. Fuel pressure 7. Fuel injector assembly 8. ECM | Comes on | DTC stored | Click here |
| P2196 *1 | Oxygen (A/F) Sensor Signal Stuck Rich (Bank 1 Sensor 1) | 1. Open or short in air fuel ratio sensor (bank 1 sensor 1) circuit 2. Air fuel ratio sensor (bank 1 sensor 1) 3. Air fuel ratio sensor heater (bank 1 sensor 1) 4. Air fuel ratio sensor heater circuit 5. Intake system 6. Fuel pressure 7. Fuel injector assembly 8. ECM | Comes on | DTC stored | Click here |
| P2237 | Oxygen (A/F) Sensor Pumping Current Circuit / Open (Bank 1 Sensor 1) | 1. Open or short in air fuel ratio sensor (bank 1 sensor 1) circuit 2. Air fuel ratio sensor (bank 1 sensor 1) 3. ECM | Comes on | DTC stored | Click here |
| P2238 | Oxygen (A/F) Sensor Pumping Current Circuit Low (Bank 1 Sensor 1) | 1. Open or short in air fuel ratio sensor (bank 1 sensor 1) circuit 2. Air fuel ratio sensor (bank 1 sensor 1) 3. ECM | Comes on | DTC stored | Click here |
| P2239 | Oxygen (A/F) Sensor Pumping Current Circuit High (Bank 1 Sensor 1) | 1. Open or short in air fuel ratio sensor (bank 1 sensor 1) circuit 2. Air fuel ratio sensor (bank 1 sensor 1) 3. ECM | Comes on | DTC stored | Click here |
| P2252 | Oxygen (A/F) Sensor Reference Ground Circuit Low (Bank 1 Sensor 1) | 1. Open or short in air fuel ratio sensor (bank 1 sensor 1) circuit 2. Air fuel ratio sensor (bank 1 sensor 1) 3. ECM | Comes on | DTC stored | Click here |
| P2253 | Oxygen (A/F) Sensor Reference Ground Circuit High (Bank 1 Sensor 1) | 1. Open or short in air fuel ratio sensor (bank 1 sensor 1) circuit 2. Air fuel ratio sensor (bank 1 sensor 1) 3. ECM | Comes on | DTC stored | Click here |
| P2A00 *1 | A/F Sensor Circuit Slow Response (Bank 1 Sensor 1) | 1. Open or short in air fuel ratio sensor (bank 1 sensor 1) circuit 2. Air fuel ratio sensor (bank 1 sensor 1) 3. Air fuel ratio sensor (bank 1 sensor 1) heater 4. ECM | Comes on | DTC stored | Click here |
- HINT:
- *1: Euro-OBD
- *2: Except Euro-OBD
- *3: Blinks when terrible misfire is detected.
- *4: for Models w/ A/T (w/ Euro-OBD).